Fleet Management & Repair Services in Winnipeg

Reefer Repair & Maintenance

We repair and maintain Thermo King and Carrier Transicold units on semi trailers, straight trucks and vans. Our technicians find the real cause of a problem instead of swapping parts until something works, and every unit is tested to make sure it holds temperature before it goes back out. To keep it that way, we put your reefers on a preventive maintenance schedule that matches how hard they work.

• Thermo King and Carrier Transicold units
• Diesel engine, compressor and belt repairs
• Controller, sensor and electrical troubleshooting
• Refrigerant leak detection, recovery and recharge
• Scheduled PM based on engine hours (typically every 3,000)

Genset Repair & Maintenance

We service, repair and maintain Carrier and Thermo King generator sets used with reefers and trailers. Regular PM keeps them producing steady, reliable power, and when something does fail, we track it down and fix it properly.

• Carrier and Thermo King gensets
• Scheduled PM: oil, filters, belts and coolant
• Engine service and load testing
• Alternator, regulator and wiring repairs
• Genset installation and mounting

Fleet Management

Running a fleet is hard enough without chasing reefer repairs. We take care of your fleet's refrigeration, power and heating needs so you can focus on moving freight. You get one point of contact, a maintenance plan for every unit, and service done at your yard so trucks aren't pulled off the road.

Every job is recorded in our Fullbay data portal, so you can check work orders, invoices and service history for each unit from any browser.

Request service online

• One point of contact for your whole fleet
• PM schedules and reminders for every unit
• Yard and after-hours servicing
• Priority breakdown response
• Service records online through Fullbay

Preventive Maintenance

Regular maintenance is the cheapest way to avoid a roadside breakdown. We set up PM for your reefers, gensets and APUs based on engine hours and how hard they work, then let you know when service is due. Running several units? Our fleet management plans cover the whole fleet.

• Service intervals based on engine hours
• Oil, filter, belt and coolant changes
• Coil cleaning and airflow checks
• Maintenance records for every unit

Trailer Heater Repair

In a Manitoba winter, a heating problem can freeze a load of produce, beverages or chemicals as quickly as a cooling failure can spoil one. We repair the heat mode on Thermo King and Carrier reefer units, as well as standalone trailer heaters, so your cargo stays above freezing all the way to the dock.

• Heat mode diagnostics on Thermo King and Carrier units
• Standalone trailer heater repair
• Thermostat, controller and wiring troubleshooting
• Fuel, blower and heating element repairs
• Pre-winter heater inspections
• Cab heaters too, including Webasto and Espar

APU Repair

An auxiliary power unit lets your drivers run heat, air conditioning and electronics without idling the engine, which saves a lot of fuel and engine wear. When the APU fails, drivers are uncomfortable and trucks sit. We find the problem and get it running again.

• System diagnostics with proper tools
• APU engine service, tune-ups and rebuilds
• Wiring, controller and alternator repairs
• Heating and A/C repairs on the APU
• Battery and charging system testing